If you are shopping for Boveda humidity packs wholesale, you already know the problem. Product that dries out loses weight, aroma, and shelf appeal, and product that stays too wet invites mold. Buying packs in bulk only helps if you pick the right relative humidity (RH) level for what you are storing.
Here is the short answer. 58% RH suits most cannabis and cured flower, 62% RH is the safer pick for longer storage and humid climates, 69% RH fits cigars and fresh product, and 72% RH is for seasoning new humidors and wood. Pack size should match container volume, so check gram capacity before you order by the case.
Below, we compare all four RH levels side by side: what each is best for, which pack sizes pair with it, and what to weigh before buying in volume. At Green Blazer, we supply pre-roll producers and retailers across the country, so we know how much consistent storage affects a finished pre-roll. We also see why bulk buyers care about authentic, fresh packs.
1. Boveda 58% RH packs
Best uses
58% RH is the default for cured cannabis flower, and it is the pack most pre-roll producers reach for first. At this level, buds stay pliable and keep their terpenes, and they sit well away from the mold risk that starts at higher humidity. It also works for hemp flower and herbal blends.
At 58% RH, flower stays smokable and stable instead of brittle or damp.
Ground material is another strong fit. Dry grind packs unevenly, so a steady 58% environment makes cone filling more consistent and cuts down on dust.
Pack sizes and coverage
Match the pack to your container volume, not to the weight of the product inside. The sizes below are the ones you will see most often in 58% RH wholesale listings. Always confirm coverage against Boveda's published sizing chart before you order a full case.
| Pack size | Typical container |
|---|---|
| 8 gram | Jars and small retail bags |
| 60 to 67 gram | Large bins and bulk bags |
| 320 gram | Totes and storage cases |
Wholesale buying tips
Start with 58% if you only stock one level. It covers the widest range of dried flower, so it is the lowest-risk bulk purchase. Before you commit to a pallet, check these:
- Buy only from an authorized source, since counterfeit packs fail to hold their RH.
- Check that the overwrap is sealed and the packs feel soft, not hard.
- Test one pack against a calibrated hygrometer after 48 hours.
- Rotate stock first in, first out, and keep unused packs in their original sealed bags.
2. Boveda 62% RH packs
Best uses
62% RH holds a little more moisture than 58%. It suits longer storage and dry climates like ours in Las Vegas, where air pulls moisture out of flower fast.
Choose 62% when dryness is your biggest risk, not mold.
Producers also use it for stock that sits on shelves for months. Flower stays springy and aromatic, though you should still stay under roughly 65% to keep mold risk low.
Pack sizes and coverage
Sizing works the same as at 58%, so match the pack to container volume. Confirm coverage on Boveda's sizing chart before ordering a case.
| Pack size | Typical container |
|---|---|
| 8 gram | Jars and retail bags |
| 67 gram | Large bins |
| 320 gram | Totes and cases |
Wholesale buying tips
Most buyers ordering Boveda humidity packs wholesale split their order between 58% and 62%. Use these checks:
- Order 62% only for dry-climate or long-hold inventory.
- Never mix 58% and 62% packs in one container.
- Verify sealed overwraps from an authorized seller.
3. Boveda 69% RH packs
Best uses
69% RH is the cigar level. Most premium cigars age best near 69 to 70%, so this is the pack for retail humidors and cigar shop display cases. It also suits tobacco-leaf products.
Use 69% for cigars, not for cured cannabis flower.
Cannabis is a different story. This level sits above the 65% line we flagged earlier, so mold risk climbs fast. Use it only for short rehydration of badly dried product, and check the stock daily.
Pack sizes and coverage
Sizing follows the same volume rule as the lower levels. Humidor capacity matters more than cigar count, so confirm coverage on Boveda's sizing chart before you order.
| Pack size | Typical container |
|---|---|
| 8 gram | Small humidors and travel cases |
| 60 gram | Large humidors and display cases |
| 320 gram | Cabinet humidors and storage cases |
Wholesale buying tips
When you buy Boveda humidity packs wholesale for cigar accounts, keep the order simple and the sourcing clean:
- Order 69% for cigar and tobacco stock, not as your flower default.
- Keep one RH level per humidor.
- Buy from an authorized seller and check that overwraps are sealed.
4. Boveda 72% RH packs
Best uses
72% RH is the seasoning pack. A new wooden humidor pulls moisture out of whatever sits inside it until the wood is saturated. Loading the bare wood with 72% first protects your cigars, and you then switch to 69% for storage.
Use 72% to season the wood, then swap to 69% once the humidor holds steady.
Keep it away from cannabis. At this level, flower reaches mold territory within days.
Pack sizes and coverage
Seasoning takes more moisture than storage, so size up when in doubt. Confirm coverage on Boveda's sizing chart before you order.
| Pack size | Typical container |
|---|---|
| 8 gram | Travel cases and small humidors |
| 60 gram | Mid-size humidors |
| 320 gram | Cabinet humidors and display cases |
Wholesale buying tips
When you buy Boveda humidity packs wholesale for retail cigar accounts, treat 72% as a small line item, not a restock staple.
- Order small quantities, since each humidor needs seasoning only once.
- Pair every 72% order with matching 69% packs for the switch.
- Buy from an authorized seller and check that overwraps are sealed.
How to buy Boveda packs wholesale
You have two legitimate routes. Boveda's own business program sells direct in case quantities, and authorized distributors resell the same factory-sealed packs. Either way, ask for proof of authorization before you pay. Counterfeits are the biggest risk when you search for Boveda humidity packs wholesale, because a fake pack looks right and then fails to hold its RH.
Buy only factory-sealed packs from Boveda or a distributor it has authorized.
Next, compare quotes on the same basis. Pricing usually drops as case size grows, but tiers differ by seller and pack size, so get written quotes instead of relying on listed prices. Use this checklist on every quote:
- Confirm the RH level and pack size on each line item.
- Ask for price per pack at each quantity tier, not just the case total.
- Check shipping cost and lead time.
- Ask how fresh the stock is, since packs have a shelf life.
- Get the return policy for damaged or unsealed packs in writing.
Finally, place a small trial order first. Test one pack of each level against a calibrated hygrometer, then scale up to full cases once the numbers hold. Mixing RH levels in a single order is fine. Mixing them in one container is not.
Choosing the right RH level for your stock
Your product decides the RH level, and everything else follows. Use 58% RH for cured flower and ground material, and move to 62% RH for dry climates or long holds. Keep 69% and 72% RH for cigars and humidor seasoning, and never let them near cannabis.
Before you place a big order for Boveda humidity packs wholesale, test one pack of each level against a calibrated hygrometer. Then buy only from an authorized source, get written quotes, and scale up to full cases once the numbers hold.
Once your storage is dialed in, the next step is what goes inside it. Green Blazer is an authorized RAW distributor in Las Vegas, so you get authentic, additive-free cones to pair with your packs. Shop authentic RAW pre-rolled cones in bulk at Green Blazer and stock your shelves with products that stay fresh and burn clean.
